TM 5-6115-275-14
NAVFAC P-8-615-14
TO 35C2-3-452-1
Section V. PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS)
4-12.
General
Preventive
maintenance
is
performed
by
organizational
maintenance
personnel
at
weekly,
monthly, and semi-annual intervals. The weekly interval
is 40 hours, monthly is 100 hours and semi-annual basis
is 500 hours. All deficiencies which are beyond the
capabilities of organizational maintenance must be
reported to Direct Support Maintenance.
4-13.
Preventive
Maintenance
Checks
and
Services
The preventive maintenance checks and services to
be performed are in Table 4-2 for the generator set less
engine. Refer to TM 5-2805-259-14 for engine
preventive maintenance checks and services. The item
numbers are listed consecutively and indicate the
sequence of minimum requirements.
Table 4-2. Organizational Preventive Maintenance Checks and Services
W -- Weekly (40 hours)
Item
Interval
Item to be
Procedures
Equipment is not
No.
Inspected
Check for and have
Ready/Available If:
repaired or adjusted
W
H
as necessary
1
•
Generator Set
Inspect entire set for loose or miss-
ing components and hardware, or
unusual wear or damage. Clean set.
2
•
Fire Extinguisher
Check to ensure seal is intact, and
extinguisher has not been used.
Replace if used.
3
•
Batteries Check battery electrolyte level.
Add water as necessary.
NOTE
In freezing weather run engine
a minimum of one hour after
adding water to batteries.
Check that the battery cables are
tight. Para 3-11, 4-27, and 4-28.
NOTE
See TM 5-2805-259-14 for
engine PMCS.
4-24 Change 5
