TM-5-6115-332-14 Generator Set Gasoline Engine Driven Skid Mounted Tubular Frame 1.5 KW Single Phase AC 120/240 V 28 V DC (Less Engine) Manual

CHAPTER 1 INTRODUCTION - TM-5-6115-332-14_30
Levels of Maintenance Accomplishments
Section II. DESCRIPTION AND DATA - TM-5-6115-332-14_32
Tabulated Data
Table   1-1   Operational   and   Organizational   Tabulated   Data
Operational and Organizational Tabulated Data -cont
Table 1-2. Direct Support and General Support Tabulated Data
CHAPTER 2
Remote-Local Switch.
Voltage Adjusting Rheostat.
Table 2-1. Controls and Instruments
Controls and Instruments (Contd)
Table 2-2. Voltmeter Indications
Operations Under Usual Conditions
Remote Mode Starting
Section II. OPERATION OF AUXILIARY EQUIPMENT
Section III. OPERATION UNDER UNUSUAL CONDITIONS
Operation at High Altitudes
CHAPTER 3 OPERATOR/CREW MAINTENANCE INSTRUCTIONS - TM-5-6115-332-14_70
Table 3-1. Consumable Maintenance and Operating Supplies
Section II. LUBRICATION INSTRUCTIONS
Table 3-2. OPERATOR/CREW PREVENTIVE MAINTENANCE CHECKS AND SERVICES - TM-5-6115-332-14_73
Section IV. TROUBLESHOOTING - TM-5-6115-332-14_74
Table 3-4. Troubleshooting
Troubleshooting (Cont'd) - TM-5-6115-332-14_77
Troubleshooting (Cont'd) - TM-5-6115-332-14_78
Troubleshooting (Cont'd) - TM-5-6115-332-14_80
Troubleshooting (Cont'd) - TM-5-6115-332-14_81
Section V. OPERATOR/CREW MAINTENANCE INSTRUCTIONS
Electrical System
Generator Assembly
CHAPTER 4 ORGANIZATIONAL   MAINTENANCE   INSTRUCTIONS
Site Selection.
Power Output Connection.
Table 4-1. Output Selector Switch Positions and Load Cable Connections (1).
Revetment Construction
Foundation and Drainage - TM-5-6115-332-14_94
Miscellaneous Construction
Orientation   Instructions.
Section II. MOVEMENT TO A NEW WORKSITE - TM-5-6115-332-14_99
Section III. REPAIR PARTS, SPECIAL TOOLS AND EQUIPMENT
Section IV. LUBRICATION   INSTRUCTIONS
Section V. PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS)
Table 4-2. ORGANIZATIONAL PREVENTIVE MAINTENANCE CHECKS AND SERVICES
Section VI. TROUBLESHOOTING
Using the Ohms Scale.
Testing for Shorts.
Testing   Resistance.
Read the meter. - TM-5-6115-332-14_118
If the AC Volts Scale is Used.
Table 4-3. Organizational Troubleshooting
Organizational Troubleshooting -cont - TM-5-6115-332-14_126
Organizational Troubleshooting -cont - TM-5-6115-332-14_127
Section VII. RADIO   INTERFERENCE   SUPPRESSION
Section VIII. MAINTENANCE OF THE ENGINE ELECTRICAL SYSTEM
Battery and Battery Frame.
The electrolyte level
Slave Receptacle and Bracket.
Time Totalizing Meter
Cleaning, Inspection and Repair. - TM-5-6115-332-14_138
Oil Pressure Indicator
Emergency   Stop-Run   Switch
Panel Light
Current Indicator Meter
Voltage Selector Switch
Circuit Breaker
Control Relays
Cleaning, Inspection and Repair. - TM-5-6115-332-14_147
Outlet Receptacle
Top Resilient Mounts
Replace Lost or Broken Terminal Clip - TM-5-6115-332-14_153
Section X. MAINTENANCE OF THE FRAME ASSEMBLY
Lifting Eye and Lifting Bracket.
Ground Stud Terminal.
Toolbox
CHAPTER 5 INTERMEDIATE (FIELD), (DIRECT AND GENERAL SUPPORT) AND DEPOT MAINTENANCE INSTRUCTIONS
Table 5-1. DS and GS Troubleshooting
DS and GS Troubleshooting (Contd) - TM-5-6115-332-14_162
DS and GS Troubleshooting (Contd) - TM-5-6115-332-14_163
DS and GS Troubleshooting (Contd) - TM-5-6115-332-14_164
DS and GS Troubleshooting (Contd) - TM-5-6115-332-14_165
DS and GS Troubleshooting (Contd) - TM-5-6115-332-14_166
Section III. GENERAL MAINTENANCE
CHAPTER 6 REMOVAL AND INSTALLATION OF MAJOR COMPONENTS
Generator - TM-5-6115-332-14_169
Generator - TM-5-6115-332-14_171
Generator -cont
Engine
Engine -cont
Installation - TM-5-6115-332-14_179
CHAPTER 7 MAINTENANCE OF THE GENERATOR SET
Output Selector Switch
Inspection.
Relay Panel and Field Flash Switch
Test Equipment and Material Required:
Locate CR5
hange setting of Multimeter
Locate VR3
Cleaning and Inspection. - TM-5-6115-332-14_192
Load Terminal Board
Remote Control Terminal Board
T e r m i n a l    B o a r d
Section II. MAINTENANCE OF THE GENERATOR
Model MEP-022A
Cleaning. - TM-5-6115-332-14_201
Assembly. - TM-5-6115-332-14_204
Cleaning. - TM-5-6115-332-14_206
Section III. MAINTENANCE OF THE FRAME ASSEMBLY
Skid Base
Cleaning, Inspection and Repair. - TM-5-6115-332-14_212
CHAPTER 8 GENERATOR SET TEST AND INSPECTION AFTER REPAIR AND   OVERHAUL
Table 8-1. Visual and Operational Inspection
Visual    and    Operational    Inspection    (Cont'd)
APPENDIX A REFERENCES - TM-5-6115-332-14_218
REFERENCES Continued
APPENDIX B BASIC ISSUE ITEMS LIST AND ITEMS TROOP INSTALLED OR AUTHORIZED LIST
Section III. ITEMS TROOP INSTALLED OR AUTHORIZED LIST - TM-5-6115-332-14_221
APPENDIX C MAINTENANCE ALLOCATION CHART - TM-5-6115-332-14_222
Explanation of Columns - TM-5-6115-332-14_223
Section II. MAINTENANCE ALLOCATION CHART
MAINTENANCE ALLOCATION CHART (Contd) - TM-5-6115-332-14_225
MAINTENANCE ALLOCATION CHART (Contd) - TM-5-6115-332-14_226
MAINTENANCE ALLOCATION CHART (Contd) - TM-5-6115-332-14_227
Section III. TOOLS, TEST AND SUPPORT EQUIPMENT REQUIREMENTS
T h e   M e t r i c   S y s t e m   a n d   E q u i v a l e n t

Western Governors University

Privacy Statement
Press Release
Contact

Integrated Publishing, Inc. - A (SDVOSB) Service Disabled Veteran Owned Small Business